Potentials of Balanite Endocarp Pod Ash as a Cement Replacement Material

Potentials of Balanite Endocarp Pod Ash as a Cement Replacement Material


DOI: 

https://doi.org/10.30564/jbms.v4i1.4800

Abstract

The exponential growth of agricultural wastes such as Balanite seed pod has resulted in waste management issues and finding alternatives through waste recycling is an interesting area of research. Balanite seed pods were collected in Yobe state, washed, dried, crushed. Balanite endocarp pod ash (BEPA) was calcined at 600 °C for 3 hours in a muffle furnace and the biomass was characterized with X-ray fluorescence spectrometer to determine its chemical composition. The analysis showed that the ash composed of silica, alumina and ferric oxide (74.24 wt.%) indicated a strong pozzolan based on American Standard. The BEPA possessed a high loss on ignition of 8.24 wt.% owing to the presence of unburnt carbon in the ash. The ash obtained was sieved with 75 µm sieve and cement was replaced with ash between 2.5 wt.% ~ 12.5 wt.% at interval of 2.5 wt.% to assess its impact on cement properties such as setting time, consistence, mortar strength and water absorption. Results showed that as percentage replacement increases, the water absorption increased while the mortar strength diminished whereas as the curing days progressed its strength improved despite clinker diminution due to cement hydration. 60 days strength for below 10 wt.% BEPA cement blend produced enhanced strength compared with control which is evidence of slow pozzolanic reactions. The optimum percentage replacement with BEPA was obtained at 7.5 wt.% replacement beyond which significantly affected the cement properties especially its strength. It could be agreed that BEPA has potentials to be considered and employed as a cement replacement material.

Keywords: 

Balanite endocarp pod ash, Consistence, Setting time, Cement replacement, Curing days

Comments

Post a Comment

Popular posts from this blog

Experimental Simulation of Red Sprites in a Laboratory

Image
Experimental Simulation of Red Sprites in a Laboratory DOI:  https://doi.org/10.30564/jasr.v5i3.4858 Abstract Over the past three decades, research of high-altitude atmospheric discharges has received a lot of attention. This paper presents the results of experimental modeling of red sprites during a discharge in low-pressure air. To initiate ionization waves in a quartz tube, an electrodeless pulseperiodic discharge fed by microsecond voltage pulses with an amplitude of a few kilovolts and a repetition rate of tens of kHz were formed. In this case ionization waves (streamers) have a length of tens of centimeters. The main plasma parameters were measured at various distances along the tube. The measurements confirm the fact that ionization waves propagate in opposite directions from the zone of the main electrodeless discharge, just as it happens during the formation of red sprites. Keywords:  Red sprites, Experimental modeling, Streamer discharge in air, Low pressures
Read more

Warmly celebrate the successful convening of the the 2024 First International Symposium on Interdisciplinary Linguistics Research！

Image
  Basic Information of the Conference Organizer:  International Academic Exchange Working Committee of China Association for the Promotion of Science and Technology, "Linguistics Research Forum" Magazine Co-organizer:  International Writing Center of International Sinology Center Undertaker:  Beijing Language Bridge Education Research and Development Center Conference Time:  20-22 December 2024 Conference Venue:  Beijing University of Posts and Telecommunications Science and Technology Building, Beijing, China 1. Conference Background     With the advancement of globalization, international exchanges and cooperation are becoming increasingly close. As an important tool for human communication, language is particularly important in research and application in different fields. The "International Symposium on Interdisciplinary Linguistics Research" came into being. Relying on the international journal "Linguistics Research Forum", this conference in...
Read more

Analysis of Chinese Citizens’ Perception and Its Differences of City Spirit: A Case Study of Hefei City

Image
Analysis of Chinese Citizens’ Perception and Its Differences of City Spirit: A Case Study of Hefei City DOI:  https://doi.org/10.30564/jgr.v5i3.4788 Abstract City spirit is the soul of the city. The spread of city spirit not only could establish a civilized specimen for citizens, but also create a good cultural atmosphere for the city. Hefei residents’ perception of city spirit is extensive, and most of Hefei citizens consider the expression words of city spirit are very appropriate, which is enlightened, open-minded, actual and innovate. Great majority of Hefei citizens willing to support the propaganda and promotion of the city spirit, and they think the promotion of the city spirit plays a key role in the way of city’s development. In addition,significant differences in the perception of urban spirituality emerge among residents with different economic and social characteristics. There are four aspects about how to enhance the public perception of city spirit, which including in...
Read more